Airtight (Gastight) Doors for VHP Sterilization & Ozone Decontamination Rooms
When a whole room is decontaminated with a gas — VHP (vaporized hydrogen peroxide) или ozone (O₃) — the cycle only works if the room actually holds the gas. That job falls to the airtight (gastight) door. A leaky door bleeds off concentration, fails the contact time, and lets the gas escape to where operators are. This guide explains why a VHP sterilization room or an ozone disinfection room needs a true gastight door, how the inflatable seal works, and how the door is built.
Why a gas-decontamination room needs a true gastight door
Room-scale gas decontamination is a concentration-and-time process: the space has to reach and hold a target gas concentration for a defined dwell so the sporicidal effect is achieved everywhere. An ordinary cleanroom door — even a good one — is not gastight; it leaks continuously. In a gas cycle that leak has three consequences:
- The cycle fails. Gas escaping through the door gap means the room never holds concentration, so the ≥6-log kill is not achieved.
- Operators are exposed. VHP and ozone are hazardous; gas leaking to the corridor is a safety problem.
- Aeration drags on. An uncontrolled boundary makes the room hard to bring back to a safe residual.
A gastight door solves all three by sealing the room’s largest opening to a leak rate low enough to validate.
The inflatable seal: gastight only when it matters
The doors in these photos use an inflatable-gasket seal — the red coiled air line at the hinge feeds a hollow silicone gasket around the door frame. During the gas cycle the gasket is inflated, pressing tight against the frame to give a gastight boundary; when the cycle ends it deflates so the door opens and closes with no wear on the seal. This is the seal of choice for rooms that are gassed regularly, because it delivers a genuine gastight closure without abrading the gasket on every use. For the full comparison with the mechanical-compression alternative, see Закрываемые двери: система с надувным уплотнением против механической системы с компрессией.
VHP sterilization room doors
In a VHP sterilization room, the gastight door lets the space be charged with vaporised hydrogen peroxide, held at concentration through the dwell, and aerated back to ≤1 ppm — all against a sealed boundary. The door typically carries a viewing window, an interlock, and a status light, and it works in concert with the room’s VHP generator and HVAC. For how the gas itself is produced and distributed, see How a VHP Generator Works и Что такое дезактивация VHP.
Ozone (O₃) disinfection room doors
An ozone disinfection room works the same way with a different gas: ozone is generated to a target ppm, held for the dwell, then catalytically destroyed before entry. Because ozone is a strong oxidiser and a respiratory hazard, the room is fitted with an O₃ concentration display and alarm and a gastight door that holds the ozone in until the concentration is safe. The door build is the same gastight, 316L stainless design.
How the door is built
| Функция | Деталь |
|---|---|
| Материалы | 316L / 304 stainless steel, smooth crevice-free surfaces, corrosion-resistant to VHP and ozone. |
| Там | Inflatable silicone gasket (gastight when inflated); mechanical-compression is the alternative for less-frequent cycles. |
| Viewing window | Flush, gasketed round or square window; laminated/tempered glass. |
| Блокировка | Electromechanical interlock (single or airlock pair) so the gas boundary is never breached mid-cycle. |
| Безопасность | Status light, gas-concentration display and alarm, emergency release. |
| Names it goes by | Airtight door, gastight door, inflatable-seal gastight door, biosafety airtight door, airlock VHP sterilization door. |
Часто задаваемые вопросы
Is an airtight cleanroom door the same as a gastight door?
No. Many “airtight” cleanroom doors only limit air leakage; a true gastight door with an inflatable seal is built to hold a hazardous gas at concentration for a validatable cycle.
Inflatable seal or mechanical compression?
Inflatable seals suit rooms gassed frequently (no wear on the gasket per cycle); mechanical compression suits lower-frequency use. See the full comparison.
Can one door serve both VHP and ozone rooms?
Yes — the gastight, 316L stainless build resists both; only the room’s generator and monitoring differ.
Сопутствующие товары
Герметичная дверь с надувным уплотнителемНадувное уплотнительное кольцо для герметичных дверей в помещениях с процедурами обработки от вредителей BSL-3/4.Перемещение и локализация
Герметичная дверь с механическим уплотнениемМеханически защелкнутая герметичная дверь для BSL-2 до BSL-4.Перемещение и локализация
Изолирующий клапан для обеспечения биобезопасностиУплотнительная мембрана изолирует системы отопления и кондиционирования воздуха во время отключения и замены оборудования BIBO.Перемещение и локализация
Система VHP с интегрированным оборудованием для отопления, вентиляции и кондиционирования воздухаКомпания VHP совместно с существующими поставщиками систем кондиционирования воздуха проведет очистку комнат и воздуховодов.Стерилизация VHPSealing a VHP or ozone decontamination room?
Tell us the room, gas and cycle frequency, and our engineers will specify the gastight door — inflatable or mechanical seal, single or airlock, with interlock, window and gas-alarm integration.